1. Welcome to Jeeps.net!

    You are currently viewing as a guest! To get full-access, you need to register for a FREE account.

    As a registered member, you’ll be able to:
    • Participate in all Jeep discussion topics
    • Transfer over your build thread from a different forum to this one
    • Communicate privately with other Jeep owners from around the world
    • Post your own photos in our Members Gallery
    • Access all special features of the site

Jeep Blew Up

Discussion in 'Wrangler TJ (1996-2006)' started by parks1217, Jan 3, 2017.

  1. Jan 3, 2017 at 6:53 AM
    #1
    parks1217

    #1
    parks1217 [OP] New Member

    Joined:
    Jan 3, 2017
    Member:
    #733
    Messages:
    1
    Gender:
    Male
    First Name:
    Parker
    Vehicle:
    2004 Jeep Wrangler SE
    Hey guys,

    I have a 2004 Jeep Wrangler SE 5-speed with a 4 cylinder 2.4 L engine. I am trying to figure out what went wrong with my engine. It is pretty tough to find these 2.4Ls around (since they kinda blow), but I've heard there are a few possibilities of what could have gone wrong.

    I was on the highway driving while it was fairly cold out (30 degrees), probably going about 75mph. When there was a sort of popping sound and then the engine shook pretty violently for a few seconds and then everything cut off and I was just coasting, could not accelerate or anything. I stopped on the ramp of an exit and popped the hood. The engine itself had a hole in it and oil had clearly been sprayed all over everything around the engine. The hole was a little smaller but about the size of a fist. I tried to start it a few times and I couldn't get it to turn over. Any way, I got it towed to my house and let it sit for about a week. I went to see what it sounded like when I tried to crank it up and it actually started to my surprise and then shook like crazy to the point where I just shut it down. I noticed there was no oil in it and put a quart in and tried the same thing. Same result except oil flew all over the place under the hood through the hole. I don't know if I have given enough information, but I am trying to see if you think I threw a rod or if it could be a freeze plug or something a little less serious. What would you do if this was you? Preciate it.
     
    parks1217, Jan 3, 2017
    #1
  2. Jan 3, 2017 at 4:55 PM
    #2
    chris4x4

    #2
    chris4x4 With sufficient thrust, pigs fly just fine Moderator

    Joined:
    Jul 19, 2016
    Member:
    #2
    Messages:
    4,068
    Gender:
    Male
    Sounds like a rod let go. If it was a freeze plug, coolant would have leaked out.
     
    chris4x4, Jan 3, 2017
    #2
  3. Jan 3, 2017 at 8:15 PM
    #3
    C2T

    #3
    C2T Well-Known Member

    Joined:
    Jul 31, 2016
    Member:
    #42
    Messages:
    763
    Gender:
    Male
    First Name:
    Richard
    Helena, Montana
    Vehicle:
    Jeep
    2.5" AEV Dual Sport lift, 35" Treadwright Guard Dogs, Black Rock Wheels, AEV Front & Rear Bumpers with Tire Carrier, Fuel Caddy 10 gal. Aux. fuel tank, Warn 9.5ti, 125' synthetic winch line, front axle skid, 20" LED light bar , Bilstein Shocks, steel steering skidplate,
    Freeze plug would not throw oil...it would throw anti-freeze. Chris is likely correct that you threw a rod. The truth is, it really does not matter much at this point. Sounds like time for a new engine.

    Of course, when all else fails...post pictures. :worthless:
     
    C2T, Jan 3, 2017
    #3
  4. Jan 4, 2017 at 7:24 PM
    #4
    OFFGRID

    #4
    OFFGRID Well-Known Member

    Joined:
    Oct 3, 2016
    Member:
    #317
    Messages:
    2,018
    Gender:
    Male
    First Name:
    Peter
    Houston
    Vehicle:
    1979 Jeep CJ7, 258, TH350, NP208
    Howell fuel injection, header, HEI distributor, TH350, NP208, SOA lift with YJ springs in the front & GW springs in the Rear. AMC20 with G2 1 piece chromos trussed, Dana 30 with G2 chromos and 760x ujoints and MM Stainless Hubs, Geared 4.56. Tom Woods shafts, Metal cloaks, Caged, 37" Toyo MTs.
    Time for an upgrade. Find a 4.0 and drop it in.
     
    OFFGRID, Jan 4, 2017
    #4
    Rc Jeep likes this.
  5. Feb 14, 2017 at 7:07 PM
    #5
    bing44

    #5
    bing44 New Member

    Joined:
    Feb 14, 2017
    Member:
    #973
    Messages:
    3
    Gender:
    Male
    First Name:
    Jim
    Vehicle:
    2005 Jeep Wrangler TJX
    2" body lift - 3" suspension lift
    I'm curious as to the outcome of this issue. While I am 99.9% sure you threw a rod, I'd like to know. I can't imagine what would poke a hole in your engine and spew oil all over the engine except for a rod. A broken valve spring can cause massive damage and I have heard of it happening but never making a hole.

    Jim
     
    bing44, Feb 14, 2017
    #5
  6. Feb 15, 2017 at 3:08 AM
    #6
    boondoc89

    #6
    boondoc89 Well-Known Member

    Joined:
    Feb 3, 2017
    Member:
    #912
    Messages:
    772
    Gender:
    Male
    First Name:
    alex
    Vehicle:
    08 JKU
    3 inch zone lift. Fox 2.0 shocks. 35 inch nitto ridge grapplers. Bushwacker flat fenders. No name steel bumpers front and back for now.
    TURBO DIESEL!!!!
     
    boondoc89, Feb 15, 2017
    #6
Register FREE to Reply!
To Top